How to Mix Types of Cement With Marble Dust | Hunker

Marble dust can be mixed with various types of cement to form precast marble molded concrete. There are two types of cement that can be mixed with marble that will form a product that is hard and resilient: type S and Portland cement.

Research Paper PARTIAL REPLACEMENT OF CEMENT WITH …

Research Paper PARTIAL REPLACEMENT OF CEMENT WITH MARBLE DUST POWDER Prof. P.A. Shirule a*, Ataur Rahman b, Rakesh D. Gupta c Address for Correspondence a*bc Dept. Of Civil Engineering, SSBT's COET, Bambhori, Jalgaon, Maharashtra – 425001 ... marble sludge dust in concrete production as partial replacement of cement. In INDIA, the marble

Partial Replacement of Fine Aggregates with Quarry Dust ...

river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.

quarry dust and marble powder in concrete

quarry rock dust in concrete pdf - mooigezicht.nl. quarry rock dust and marble sludge powder separately, quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand at 50% Inquiry Use of Crushed Granite Fine as Replacement to River Sand,

BEHAVIOUR OF CONCRETE BY PARTIAL REPLACEMENT OF ... - YouTube

Dec 14, 2015· behaviour of concrete by partial replacement of cement and sand with marble powder and quarry dust

Use of Quarry Dust as fine aggregates by Partial ...

to study the feasibility of the usage of quarry rock dust and marble sludge powder as hundred percent substitutes for natural sand in concrete. Two sample of M20 mixes were prepared using Grade-43 OPC, one with quarry dust and another by marble sludge powder combination. It was concluded that quarry dust and marble sludge powder

Experimental Study on Concrete Using Waste Marble Powder ...

marble powder and quarry dust as partial replacement of cement and fine aggregate in concrete and comparing it with conventional concrete. The quarry dust in place of sand is replaced with 25% and waste marble powder in place of cement is replaced partially with various percentages (2.5%, 5%, 7.5%, 10%, 12.5%, and 15%). This

Crushed Stone vs. Quarry Process vs. Stone Dust

Quarry process, also known as QP, dense grade aggregate (DGA), crusher run and road stone, is a combination of small, 3/4-inch-or-less crushed stone and stone dust. Most often it is made out of crushed limestone, granite-gneiss, trap rock or a combination of the aforementioned.

Comparative study on Strength Characteristics of Concrete ...

of marble powder and quarry dust decreases the compressive strength. 3) As the water cement ratio is more, there is a decrease in workability. 4) Quarry dust was a better partial replacement of cement in concrete than the marble powder because it shows good strength and other properties of concrete.

replacement of fine aggregate with marble dust pdf

Properties of green concrete containing quarry rock dust and marble ... DUST AND MARBLE SLUDGE POWDER AS FINE AGGREGATE ... Through reaction with the concrete admixture, Marble sludge powder and quarry rock dust improved pozzolanic ..... effect is …

EXPERIMENTAL STUDY ON PARTIAL REPLACEMENT OF …

marble dust in the cement concrete gives the best results. And also increase in curing days will increase the strength of marble dust concrete when compared from 14 days to 28 days. Rakesh Gupta studied on "Partial replacement of cement with marble powder" and

quarry dust and marble powder in concrete

Influence of Marble powder, quarry dust and marble powder in concrete, and quarry dust [7] for use in traditional concrete Quarry dust is a Read More Portland concrete, the basic ingredient of concrete, is a closely controlled chemical combination of calcium, silicon, aluminum, iron and small amounts of other ....

Can we make concrete using quarry dust as a replacement ...

Jul 01, 2017· Can we make concrete using quarry dust as a replacement for sand? ... Granite dust might be fine (no pun intended) but marble dust, probably not. Reactive aggregates could result in weak concrete or cause long-term deterioration. Concrete mix design is a complex subject and is a specialty; usually ready-mix suppliers have standard mix designs ...

EFFECT ON STRENGTH AND DURABILITY PROPERTIES OF …

developed by partial replacement of sand with granite quarry dust (GD) and cement with marble powder (MP) in concrete. In this paper, a study is conducted to investigate the viable use of marble granite residue (MGR) in concrete mixes. Sand is replaced with GD along with cement (OPC grade 43)

Properties of green concrete containing quarry rock dust ...

Through reaction with the concrete admixture, Marble sludge powder and quarry rock dust improved pozzolanic reaction, micro-aggregate filling, and concrete durability.

replacement of sand by marble powder in concrete

river sand. Quarry dust and Marble powder contains similar properties as that of river sand and hence accepted as a building material. The present paper focuses on investigating maximum percentage replacement of river sand by Quarry dust and Marble powder in varying equal percentages 0%, 10%, 20%, 30%, 40%, 50%, and 60% for M25 mix designations.

Influence of limestone waste as partial replacement ...

They concluded that the replacement of fine aggregate with 50% marble powder and 50% quarry rock dust green concrete gives an excellent result in workability and it satisfy the self compacting concrete performance which is the slump flow is 657 mm without affecting the strength of concrete. Slump flow increases with the increase of marble ...

Experimental study on partial replacement of cement by ...

found that the studies of concrete made of waste marble powder and quarry sand increases at 10% and 40% respectively. Therefore the quarry dust and waste marble powder should be used in construction works, then the cost of construction would be saved significantly and the natural resources would be used efficiently. Keywords-Marble Powder ...

EXPERIMENTAL INVESTIGATION ON PARTIAL …

marble powder and quarry dust is generated as a by product cutting marble powder and quarry dust. The waste generated every year is in tones which dumped open space. The environmental problems attributed by waste marble powder and quarry dust imposes to physical, chemical, biological components of environments. It is therefore very

Green Concrete by using Industrial Waste Material- fly ash ...

Dhoka (2013), carried out "green concrete: using industrial waste of marble powder, quarry dust and paper pulp" The green concrete is prepared by using industrial waste of marble powder, quarry dust with proper proportions". The versatility of green concrete & …

EXPERIMENTAL STUDY ON CONCRETE BY PARTIAL …

are casted with different percentage of Marble Dust Powder, Quarry Dust and Coconut Shell content in concrete has been investigated. After curing, the specimens were tested at 7, 14 and 28 days. The optimum percentage of Marble Dust Powder, Quarry Dust and Coconut Shell were also again casted and tested at 7, 14 and 28 days. ) 3

"Green Concrete: Using Industrial Waste of Marble Powder ...

From the above study, it is concluded that the quarry rock dust and marble sludge powder may be used as a replacement material for fine aggregate. The replacement of fine aggregate with 50% marble sludge powder and 50% Quarry rock dust (Green concrete) gives an excellent result in strength aspect and quality aspect.

Influence of Marble Powder Mortar and Concrete Mix

This paper aims to focus on the possibilities of using waste materials from differentmanufacturing activities in the preparation of innovative mortar and concrete. The use of waste marble powder (dust) was proposed in partial replacement of cement, for the production of Mortar and Concrete Mix.

Marble Powder and Quarry Dust as Apartial Replacement for ...

the characteristic strength of concrete using quarry dust and marble powder as partial replacement of fine aggregate tested at 7 and 28 days in M30 concrete. To replace the fine aggregate partially by using quarry dust and marble powder mix in various proportion.Compare the compressive and split

Marble Powder and Quarry Dust as Apartial Replacement for ...

the characteristic strength of concrete using quarry dust and. marble powder as partial replacement of fine aggregate tested at 7 and 28 days in M30 concrete. To replace the fine aggregate partially by using quarry dust and marble powder mix in various proportion.Compare the compressive and split tensile strength of replaced concrete specimen ...

disadvantages of quarry dust uses in concrete

The effect of the using waste marble dust as fine sand on the ... In this experimental study, the effects of using waste marble dust (WMD) as a fine material on the ... Key words: Waste marble dust, very fine sand, concrete, dynamic modulus of ..... containing quarry rock dust and marble sludge powder …

THE EFFECT OF QUARRY DUST WITH CEMENT BY-PRODUCTS ON ...

Hameed, and Sekar. (2009). Properties of Green Concrete Containing Quarry Rock Dust and Marble Sludge Powder as Fine Aggregate. Hmaid Mir, A. (2015). Improved Concrete Properties Using Quarry Dust as Replacement for Natural Sand. International Journal of …

Study on Compressive Strength of Quarry Dust as Fine ...

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...